| Public Health Service Food and Drug Administration |
| Seattle District Pacific Region 22201 23rd Drive SE Bothell, WA 98021-4421 Telephone: 425-486-8788 FAX: 425-483-4996 |
Department of Health and Human ServicesFebruary 11, 2010
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
In reply refer to Warning Letter SEA 10-11
Christopher T. Rangen, President
Rangen, Inc.
115-13th Avenue South
PO Box 706
Buhl, Idaho 83316
WARNING LETTER
Dear Mr. Rangen:
On June 9-11, 2009, U.S. Food and Drug Administration (FDA) investigators inspected your animal feed manufacturing facilities located at 115-13th Avenue South, Buhl, Idaho. The inspection revealed significant deviations from the requirements set forth in Title 21, Code of Federal Regulations, Section 589.2000 (21 C.F.R. 589.2000), Animal Proteins Prohibited in Ruminant Feed. This regulation is intended to prevent the establishment and amplification of Bovine Spongiform Encephalopathy (BSE). You failed to follow the requirements of this regulation, resulting in products being manufactured and distributed by your facility that were adulterated within the meaning of section 402(a)(4) of the Federal Food, Drug, and Cosmetic Act (the Act), 21 U.S.C. § 342(a)(4), and misbranded within the meaning of section 403(a)(1) of the Act, 21 U.S.C. § 343(a)(1). Our investigation determined that adulteration resulted from the failure of your firm to provide for measures to avoid commingling or cross-contamination. The adulterated feed was subsequently misbranded because it was not properly labeled. Specifically,
we found:
1. Your firm failed to provide for and use cleanout procedures or other means adequate to prevent carry-over of products that contain or may contain proteins derived from mammalian tissues into animal feed that may be used for ruminants, as required by 21 CFR 589.2000(e)(1)(iii)(B). Since your feed is prepared, packed, or held under these conditions it is, therefore, adulterated under section 402(a)(4) of the Act, 21 U.S.C. § 342(a)(4).
• Mink feed that was not labeled "Do not feed to cattle or other ruminants," in accordance with 21 CFR 589.2000(e)(1)(i) and that, therefore, might be fed to ruminants, was produced using the same equipment as aquaculture feed that contains proteins derived from mammalian tissues, such as meat and bone meal. You conducted no clean-outs or flushes of equipment to remove proteins derived from mammalian tissues that may have been present before manufacturing the mink feed that might be fed to ruminants.
• The auger trucks you used to deliver bulk mink feed which contained or may have contained proteins derived from mammalian tissues were not subject to an effective clean-out prior to their use to deliver bulk animal feed, including ruminant feed, that did not contain such materials. There were no procedures to clean the trucks to remove proteins derived from mammalian tissues before shipment of animal feeds that did not contain such materials.
2. You failed to label all products which contained or may have contained proteins derived from mammalian tissues with the statement, "Do not feed to cattle or other ruminants," as required by 21 C.F.R. 589.2000(e)(1)(i). Such products are misbranded under Section 403(a)(1) of the Act, 21 U.S.C. § 343(a)(1). The misbranded product includes bulk mink feed.
• On June 9, 2009, the investigators observed approximately (b)(4) pallets of (b)(4) 50 pound bags of (b)(4) MINK FEED, lot 06/05/09. All bagged mink feed, as well as approximately (b)(4)% of bulk mink feed, manufactured at your facility, was produced using the aquaculture feed production equipment used to produce feed containing proteins derived from mammalian tissues. Because mink feed produced using this equipment may have contained mammalian tissues, it was not properly labeled, as required by 21 C.F.R. 589.2000(e)(1)(i).
This letter is not intended to serve as an all-inclusive list of violations at your facility. As a manufacturer of materials intended for animal feed use, you are responsible for ensuring your overall operation and the products you manufacture and distribute are in compliance with the law. You should take prompt action to correct the above violations and you should establish a system whereby violations do not occur. Failure to promptly correct these violations may result in regulatory action, such seizure and/or injunction, without further notice.
We acknowledge your July 31, 2009 letter detailing procedures you had implemented or planned to implement to prevent future violations of FDA regulations relating to mammalian proteins in animal feed. In particular the letter stated that Rangen would no longer purchase meat and bone meal for use in any of its animal feeds and that existing inventories of mammalian protein ingredients would be exhausted by December 31, 2009. Division Manager, Joy Kinyon made similar assertions in the course of FDA's June 2009 inspection. The July 31, 2009 letter further set out procedures Rangen would use to remedy observed violations of FDA regulations while mammalian proteins were still being used at Rangen. Finally you explained steps taken to recover or relabel feed that may have been contaminated due to commingling resulting from your manufacturing and distribution procedures. Within fifteen (15) working days of receiving this letter you should, in writing, confirm the steps you took prior to receiving this letter and notify FDA of steps you have taken since receiving this letter to bring your firm into compliance with the law. Your response should include each step that has been taken or will be taken to correct the violations and prevent their recurrence. If corrective action cannot be completed within fifteen (15) working days, state the reason for the delay and the time frame within which the corrections will be completed. Please include copies of any available documentation demonstrating that corrections have been made.
Your written reply should be directed to Scott A. Nabe, Compliance Officer, U.S. Food and Drug Administration, 22201 23rd Drive SE, Bothell, Washington 98021-4421. If you have any questions about this letter, please contact Mr. Nabe at (425) 483-4753.
Sincerely,
/s/
Charles M. Breen
District Director
Seattle District
cc: Joy A. Kinyon, Division Manager, Aquaculture Feeds-General Feeds
Rangen, Inc.
PO Box 706
115-13th Avenue South
Buhl, Idaho 83316
No comments:
Post a Comment